Intake heater light on freightliner - Ok so I'm working on a MT45 Freightliner with a 6.7 cummins. Are there two intake air heaters or just one? I only see the one that sits in between the upper intake horn and the lower intake? The truck is throwing a Check engine code 70 (inlet air heater driver #1 fault> mode 13-out of calibration).

 
I have a 2004 FREIGHTLINER M2-16 with a DT 466 Diesel engine. While driving it it runs fine but at decceleration at almost full stop, it starts shaking and acting up and the intake heater light comes … read more. Goodness of god chords pdf key of d

EZWiring EZWiring™ makes Freightliner, Sterling, Western Star, Thomas Built Buses, and Freightliner Custom Chassis Corporation products’ wiring drawings and floating pin lists available online for viewing and printing. EZWiring can also be ac-cessed from within PartsPro. Introduction Descriptions of Service Publications Freightliner Custom Chassis ... 09 Air Intake . 09–01 Air Cleaner Element Inspection and Replacement ; 13 Air Compressor . ... 83 Heater and Air Conditioner . 83–00 Safety Precautions ; 83–01 Air Conditioner Inspecting ; 83–02 HVAC Air Filter Replacing ; 88 Hood, Grille, and Cab Fenders ...Originally posted by dsalinas1939. i may have put this up before not sure but i have this 2014 c2 and its setting a 3494 code its intake heater mechanical fault i ran down the diagnostic tree and its tellin me it have to take to dealer for next procedure the heater eliment is working fine when i turn key on i hear it click on then off i see it ... BUSINESS CLASS M2 MAINTENANCE MANUAL Models: M2 100 M2 106 M2 106V M2 112 M2 112V STI-455-7 (02/03/2022) Published by Daimler Truck North America LLC 4747 N. Channel Ave. Intake Heater Light: Troubleshooting Tips for Bus & Freightliner | JustAnswer. Ask an Expert. Car Questions. Truck Repair. This answer was rated: …2) The intake air heater circuits will only activate when the intake manifold temperature is below 19°C [66°F] when the key switch is in the ON position. Ask Your Own Medium and Heavy Trucks Question. Voltmeter on dash Drops down every time the relay cycle When cold I turn the key on I hear the relays energize and the wait to start light ...Shouldn't the intake heater indicator stay on longer than 2-3 seconds on cold mornings ? If I could find the relay I'd like to test it to see if it is faulty. 0 likesJan 22, 2024 · I have a 2004 FREIGHTLINER M2-16 with a DT 466 Diesel engine. While driving it it runs fine but at decceleration at almost full stop, it starts shaking and acting up and the intake heater light comes … read more Benefits of Solar Water Heaters - The benefits of solar water heaters are numerous. Visit HowStuffWorks to learn all the benefits of solar water heaters. Advertisement The benefits...Originally posted by dsalinas1939. i may have put this up before not sure but i have this 2014 c2 and its setting a 3494 code its intake heater mechanical fault i ran down the diagnostic tree and its tellin me it have to take to dealer for next procedure the heater eliment is working fine when i turn key on i hear it click on then off i see it ...Instructions for Westek timers are available online at AmerTac.com and WaterHeaterTimer.org. American Tack and Hardware Co. manufactures and distributes Westek timers for use in ap...Find the intake air heater and then find the leads to that heater. Disconnect the leads and check for resistance at those leads. You can check Youtube on how to do it. If your intake air heater is not heating up and if there is no voltage drop because of the electrical load that is not placed on the intake air heater then you can potentially ...The ABS light is a steady burn while cranking but once it fires it flashes for about 30 sec before going off. ... It **might** have an intake heater. It would be on the air intake pipe going in to the engine and have a couple of 2 gauge or so cables gojng to it. ... Freightliner used to bury them under there on the business class trucks. I ... With the results, contact Mercedes-Benz Transmissions Service Support by fax (503.961.8435), email (MBTServiceSupport@ Freightliner.com), or phone (503.745.4965 or 503.745.4988). Table 2, The Battery Voltage Is Too Low 307/4 Business Class M2 Workshop Manual, Supplement 20, September 2011... Thanks for the information. The 2 wire sensor is the intake air temp sensor. The 3 wire sensor is the Boost pressure sensor. Thr boost has nothing to do with the intake heater. The other sensor is the coolant temp sensor. It is located in the top of the block on the drivers side. It ia a 2 wire sensor as well.Here I show how to diagnose a air intake heater circuit on a Cummins Isc EngineSep 23, 2018 · CODES: Fault Code: 2555. PID (P), SID (S): S070. SPN: 729. FMI: 3. Lamp: Amber. REASON: Intake Air Heater 1 Circuit - Voltage Above Normal or Shorted to High Source. High voltage detected at the intake air heater signal circuit. EFFECT: The intake air heaters may be ON or OFF all the time. The heater will stay on for a few minutes, It is there to help starting and reduce smoke during warmup.i haven't worked on cats in a few years but i think the heater can stay on for up to 5 minutes in extremely cold environments. and yes they will draw voltage down .On our Freightliner m2 trucks with cummins engines,the intake heater will cycle ...Wait to Start light does not come on in the dashboard. Truck will start but is difficult especially in colder temps now. ... My question is about the air intake heater system on my 2000 Freightliner FL70 that has a Cat 3126 engine. I have had the truck since March of this year. Initially the indicator light for warming the ...Freightliner Trucks reserves the right to discontinue models and to change specifications or design at any time without notice and without incurring obligation. Descriptions and …Intake Grid Heater light. Have a 2002 7.3 F-350. Just started having the intake heater light stay on while driving it all the time also noticed a small amount of white smoke on start up. I've read that it shouldnt be on because I'm driving, above 32* F, BLAH BLAH. Wondered if I deleted it would that fix the light or is it a relay problem.Benefits of Solar Water Heaters - The benefits of solar water heaters are numerous. Visit HowStuffWorks to learn all the benefits of solar water heaters. Advertisement The benefits...There is a heater element that can be between 750 and 1,500 watts that extends into the engine's cooling jacket. The benefit to this system is that you don't have any heater hoses to worry about replacing or leaking and the heat is put directly into the engine, where it's more efficient. ... As soon as the light goes out, the intake manifold ...My grid heater is not firing up on my 6.7. It is in the single digits at night and no where near the 55 or 60 F function point. I checked the power to the main solonoid that controls power to the grid and I also manually fired the solonoid and varified that it is working. The problem seems to be that the ECM is not giving a command to activate ...Ok so I'm working on a MT45 Freightliner with a 6.7 cummins. Are there two intake air heaters or just one? I only see the one that sits in between the upper intake horn and the lower intake? The truck is throwing a Check engine code 70 (inlet air heater driver #1 fault> mode 13-out of calibration).My 2019 freightliner has a intake heater light that keeps flashing when I hit a bump going down the road or when I - Answered by a verified Technician163. Wait to start light is not coming on. But engine starts. The wait to start light is for the engine intake air heater. When key is first turned on, all the lights on the dash come on for a couple of seconds, including the wait to start light. But it used to stay on for a few seconds after that, then go off signaling it was time to turn the ... 808 Posts. Posted - 05/30/2017 : 10:18:04 AM. I have a DT466 that we got back from the dealer . They had to do some work on the engine we installed . There were wiring issues . When we got it back the wait to start light would come on for 5 or 6 seconds and go off . A couple days later went to start the bus the wait to start light wouldn't come ... We have had numerous inake heater relays fail on 3116/3126 engines. The C7 engines use a heavier relay. The earlier relays are to small to carry the 90+ amp load. On the 3116/3126 engines we have been using the Blue Bird relay that is used for the body heater/light functions. It does require replacing the terminal ends with something much …The grid heater will take your voltage down quite a bit that's why it's a good idea to let the light go off before you try and start it, crank for 10 sec wait for 30 sec it should fire-up then. ... If my memory serves me correctly the intake heater relay is a Freightliner part and they are cheap follow the #4 cable back from the grid heater ...Cummins FC 383 Intake Heater Zach Melton 3 posts since Dec 8, 2014 Cummins FC 383 Intake Heater Jan 4, 2021 8:17 PM Had a Unit (MJ0424) with 7k miles on it in the shop for an Active 383 fault for the Intake Heater relay Current low or Open. When driving the unit I could hear the relay activate and the Dash voltmeter would drop as expected.Jan 18, 2023 · 3 posts · Joined 2023. #1 · Jan 18, 2023. I have a 2004 ram 2500 5.9 with 73k miles and a couple months ago the check engine light came on for the air intake heater. I replaced the air intake heater as well as the relays. Light stayed on and would not clear with the scanner. Took it to the dealer and they said the air intake heater and relays ... The CAT C7 '07 engine coolant heater is an option listed for the Blue Bird school bus products; BBCV, A3FE, and A3RE. OPTION #40168 BLOCK HEATER, INTERNAL. Internal engine block heater (coolant immersion type). Considered a coolant heater starting aid. 120V AC and 1500 watts; includes a standard lead power cord. BB Quality Educator. Thomasbus24.Mar 21, 2010. #1. Recently I disconnected my battery cables, pulled the speedometer out to look for something else and now my check engine light and engine heater light won't go out and the code it flashes is 49 which is "Inlet Air Heater Driver Fault" (open/closed circuit) or something like that. I called CAT and he said it could be anything ...Originally posted by dsalinas1939. i may have put this up before not sure but i have this 2014 c2 and its setting a 3494 code its intake heater mechanical fault i ran down the diagnostic tree and its tellin me it have to take to dealer for next procedure the heater eliment is working fine when i turn key on i hear it click on then off i see it ...Mar 29, 2012 · banyon. If the grid heater was on you would see the draw on the amp meter. Keep a test light in the truck with you & when it comes on see if the grid solenoid is getting power. It should have power to one side but not to the grid itself. The intake air sensor is the one at the air cleaner. FREIGHTLINER M2 Heater Assembly. OEM #: A22-59312-000. SURPLUS RED DOT AUXILARY HVAC A/C HEATER ASSEMBLY FLOOR MOUNTED P/N: A22-59312-000 REPLACED BY P/N: RDH R4225 1. Create Estimate. Part Info. (541)922-6455 Request Info Enterprise Hagerman Inc. UMATILLA OR. $600.00. ok, attached is a pin diagram for the air heater. check all fuses with a test light for power on both sides key on. Roy. As I said, I'm not near the vehicle, so will have to try this out later. Thanks. Ask Your Own Medium and Heavy Trucks Question. Hello, the engine number is ***** Ref No is C01-00003-394. S2 Chassis Maintenance Manual, November 201942/9. 5. Check the fuse for the hydraulic brake booster pump, as follows. 5.1 Open the cover to the main power distri- bution module (PDM). 5.2 Pull the fuse in position F6 for the Hydro- Max relay. 5.3 Inspect the relay to make sure the fuse is not damaged.I operate a 2010 Freightliner M2- 112 with an MBE4000 mercedes engine. It has about 20k on it. It has an "intake heater" flashing light on the dash that the dealer can't seem to find the cause of. The closest dealer is over an hour away, so it takes a lot of time to take it there. When...grid heater (P/N: EA0001595204). Note that paint on the engine may hide the true color of the grid heater. A small amount of paint may have to be scraped off the grid heater to find it’s true color. 6. Mount the relay (P/N: A0045459205) to the relay bracket (P/N: A9061531340) using supplied M6x12 bolts (P/N: N910105006002)Saf-T-Liner C2 School Bus Maintenance Manual. Foreword. Introduction. 00 General Information. 01 Engine. 08 Electric Drive. 09 Air Intake. 13 Air Compressor. 15 Alternators and Starters.2020 freightliner M2-106 with 3 lights on.1 Check engine light. 2 Amber engine light 3. Amber low Def light with blinking red light. My def tank if full but keeps indicating i have no def fluid. Drove … read moreThe heater core in the Chevy Astro van acts like a small radiator that the engine coolant passes through. If the van's heater has trouble working, you may need to replace the core....2 Vehicle Access. Assist Rails and Access Steps. Entering and Exiting the Bus. Front Door Opening and Closing. Battery Access. Hood Opening and Closing. Emergency Roof Escape Hatch. Emergency Door. Emergency Window Exits.i have fl 8o with 3126 intake heater light will stay on or keeps coming on draining my alternator. Answered in 6 minutes by: Technician: Cat Man. Hi. Thanks for using JA! I will try and help you out. The most likely cause of your problem is a faulty Inlet Heater relay. I have seen this before. The relay is located on top of the engine and ...255 posts · Joined 2005. #1 · Dec 30, 2007. My dad has a Bluebird bus (Frieghtliner chassis) with a 2000 CAT 3126 engine. Since the weather turned cold here in CA (33 degrees F overnight) the engine has been more difficult to start. It is taking 6 or so 30 second cranks to get it started.Have a cat 3126, I suspect air inlet heater is not working. Lots of smoke at startup, light comes on but not for long. How can I test it or the relay. 02 kw t300 cat 3126 engine. Hello and thank you for using just answer my name is ***** ***** I will be assisting you with your question today on your intake heater on your caterpillar engine ...Re: CAT 3126B "Wait to Start" Light. « Reply #4 on: October 23, 2012, 05:05:05 PM ». Rod, Certainly sounds like a loose connection or the pre-heat relay/solenoid with the points sticking. Locate the relay. With a voltmeter, check for 12 VDC on the large wire out to the intake heater when someone turn the key on.09 Air Intake . 09–01 Air Cleaner Inspection ; 13 Air Compressor . 13–00 Safety Precautions ; 13–01 Air Compressor Inspection ; 15 Alternators and Starters . 15–00 Safety Precautions ; 15–01 Alternator, Battery, and Starter Connections Check ; 20 Engine Cooling/Radiator . 20–00 Safety Precautions ; 20–01 Pressure Relief Cap Check09 Air Intake . 09–01 Air Cleaner Element Inspection and Replacement ; 13 Air Compressor . 13–00 Safety Precautions ; 13–01 Air Compressor Inspection ; 15 Alternators and Starters . 15–00 Safety Precautions ; 15–01 Alternator, Battery, and Starter Checking ; 20 Engine Cooling/Radiator . 20–00 Safety Precautions ; 20–01 Radiator ...Propane heaters can make cold winter nights a lot more bearable. Here's a list of some of the best indoor and outdoor propane heaters to keep you warm this winter season. If you bu...open a can of worms. essentially there have been. a few cases of the grid heater bolt breaking off and finding a home pounded into the top of cylinder 6. the belief is the bolt loosens and electrical current arcs causing it to fall off, or constant elec current arcs causing it to fall into intake.Blog Entries: 1. CAT 3126 does not have glow plugs and uses an air intake pre heater. Not sure there is a fuse for that but check the wiring diagram for your coach and see. Or, a visit to a CAT shop. __________________. 2007 Country Coach Allure Siskiyou Summit, sold/traded Nov. 2018. 2019 Grand Designs 384GK-R 5th wheel.Freightliner BUSINESS CLASS M2 – fuse box diagram Year of production: Main Fuse Box Number Function Ampere ratting [A] F1 VCU (MBE900 only) 10 F2 Blower Motor 30 F3 Engine ECU 20 F4 Transmission Control Unit 30 F5 Ignition Switch 5 F6 Spare — F7 Bulkhead Module 30 F8 ICU 10 F9 Transmission Control Unit …Intake heater light keeps coming o. And off and truck won’t maintain speed. Mechanic's Assistant: Sometimes things that you think will be really complicated end up being easy to fix.There is a heater element that can be between 750 and 1,500 watts that extends into the engine's cooling jacket. The benefit to this system is that you don't have any heater hoses to worry about replacing or leaking and the heat is put directly into the engine, where it's more efficient. ... As soon as the light goes out, the intake manifold ...Find somewhere else to keep these household objects. In addition to using less energy, part of the appeal of tankless hot water heaters is that they take up less space than traditi...EZWiring EZWiring™ makes Freightliner, Sterling, Western Star, Thomas Built Buses, and Freightliner Custom Chassis Corporation products’ wiring drawings and floating pin lists available online for viewing and printing. EZWiring can also be ac-cessed from within PartsPro. Introduction Descriptions of Service PublicationsThe CAT C7 '07 engine coolant heater is an option listed for the Blue Bird school bus products; BBCV, A3FE, and A3RE. OPTION #40168 BLOCK HEATER, INTERNAL. Internal engine block heater (coolant immersion type). Considered a coolant heater starting aid. 120V AC and 1500 watts; includes a standard lead power cord. BB Quality Educator. Thomasbus24. To contact Freightliner about a concern about a specific vehicle call the Customer Assistance Cen-ter at 1-800-385-4357 or complete a Product Concern Form. Vehicles domiciled in Canada that are thought to have a defect that could cause a crash, injury, or death, should immediately be reported to Trans-port Canada and Daimler Truck North ... summary: freightliner service campaign: see document search button for owner letter. freightliner columbia front air brake hoses-air products inc. only. on certain trucks, an elbow fitting connecting the brake air line hose to the front brake cha . communication number: sb-54-240, date: 2009-06-01 category: 111000 electrical system:batteryFl70 with a cat 3126. the intake heater light does not come on. and won't start without ether. 2002. Replaced the intake - Answered by a verified Technician. We use cookies to give you the best possible experience on our website. ... Hi, I have a 3126 CAT engine in a 1997 Freightliner FL-70.TWR. 1940 posts · Joined 2011. #3 · Jan 19, 2016. check the intake manifold air temperature sensor this sensor tells the ECM when to turn the grid heater on by what temp the intake is as i recall anything under 66 degrees it does not turn the heater on anything below 66 at start it turns it on the grid heater.EZWiring EZWiring™ makes Freightliner, Sterling, Western Star, Thomas Built Buses, and Freightliner Custom Chassis Corporation products’ wiring drawings and floating pin lists available online for viewing and printing. EZWiring can also be ac-cessed from within PartsPro. Introduction Descriptions of Service PublicationsThe heater core in the Chevy Astro van acts like a small radiator that the engine coolant passes through. If the van's heater has trouble working, you may need to replace the core....Leading Solutions for Cold Starts & Emissions Reduction. Air Intake Heaters, also known as grid and manifold heaters, provide solutions for diesel applications such as On-Highway, Off-Road and Power Generation. Powered by the vehicle battery, air intake heaters provide an on-board, stand-alone cold weather starting aid without driver intervention.Cummins isb6.7 in a freightliner m2 106. an intake heater was ordered for this unit wich is a 6hr job all the fuel line need to be removed. I looked atvthe c...Grid heater light kicked on while driving. so just got the truck with 170,000 and was perfectly fine ( dealer let me take it home for a few days). Then dealer threw in a smarty programmer he had ordered for it and i set it on level one to start with. I took it down the highway and when cruising at 70 the wts light kicked on and chimed a few times.Here are some of the best outdoor heaters for restaurants to keep your customers warm and cozy when they want to dine outdoors to enjoy a meal. If you buy something through our lin...Jun 12, 2017 · Posts: 944. Check Engine Light - Grid Heater. I have a CAT C-7 (350 HP) in a Travel Supreme motorhome with a check engine light illuminated due to the following codes: 70-5: Inlet Air Heater Driver #1. 729-5: Air Intake Heater Open Circuit. I checked the grid heater solenoid and it is good, but it appears I am not getting control power to the ... Cummins FC 383 Intake Heater Zach Melton 3 posts since Dec 8, 2014 Cummins FC 383 Intake Heater Jan 4, 2021 8:17 PM ... I also hooked a load light to the stud on the heater to verify there is voltage going to the Heater. Cummins Troubleshooting states the resistance of the Relay control side should be a minimum of 30 ohms.Table of contents Freghtliner Cascadia Trucks Dashboard Symbols & Warning Lights Freightliner Cascadia Truck Operation Manual About Freightliner Trucks Freghtliner is a German truck manufacturer that has been in the market since 1946. The company is known for its robust and durable trucks. They are known for their innovative and ground-breaking designs, which have helped […]My 2019 freightliner has a intake heater light that keeps flashing when I hit a bump going down the road or when I - Answered by a verified TechnicianThere can be numerous reasons/causes for this code failure. 1. Test the individual and total injector return rates now. May be damaged injector nut, tube hole, rust in threads. 2. Test the output i.e. measure the output of the lift pump and the CP3, if either are low in volume or pressure, will cause the code. 3.76 posts · Joined 2011. #1 · Jul 30, 2011. I was driving today and the wait to start/glow plug light started flashing along with chimes. Now it's on permanently. Anyone know why that is. All other gauges read ok. No check engine light and truck starts and shuts down as normal. Any help would be appreciated.Also the intake heater light on the dash comes on then stays on but is very dim, even with the engine warm. Mechanic's Assistant: ... My question is about the air intake heater system on my 2000 Freightliner FL70 that has a Cat 3126 engine. I have had the truck since March of this year.CASCADIA MAINTENANCE MANUAL Models: CA113DC CA113SLP CA125DC CA125SLP STI-478-6 (02/03/2022) Published by Daimler Truck North America LLC 4747 N. Channel Ave. Portland, OR 97217Air intake restriction vacuum is measured in inches of water (inH 2 O). For vehicles equipped with a graduated indicator or a restriction gauge on the dash, check the gauge with the engine off. If the yellow signal stays locked in the red zone once the engine is shut down, or is at or above 25 inH 2 O, the air cleaner element needs to be replaced.11. Inspect the intake pressure/temperature sensor and wiring connector for signs of damaged, bent, spread, corroded or unseated (pushed out) pins and signs of moisture in the connector or wire damage near the connector. Is there any sign of damage present? a. Yes; repair as necessary. Go to step 16. b. No; replace intake pressure/temperature ...Here is what this code means: “Exhaust Emission Controller aftertreatent 1 intake gas sensor heater control mechanism system not responding or out of alignment.” That is a mouthful to say and to write. What this means is that the “NOx Raw Sensor not ready after Dewpoint enable inspection”. In other words, the sensor failed to activate.Oct 24, 2021 · This discussion is proudly sponsored by: Please support our sponsors and let them know you heard about their products on iRV2. Thread Tools. 10-24-2021, 04:48 PM. BobG88. Senior Member. Join Date: Jul 2016. Location: Murfreesboro, TN. Posts: 356. The result of sustained, concentrated investment, the Cascadia represents a new era in trucking for Freightliner in Australia and New Zealand. Find everything you need to know about the 116 and 126 models. Trucks. Why Cascadia. Cascadia 116. Cascadia 126. Engines & Transmissions. Detroit Systems. About Freightliner. BUSINESS CLASS M2 MAINTENANCE MANUAL Models: M2 100 M2 106 M2 106V M2 112 M2 112V STI-455-7 (02/03/2022) Published by Daimler Truck North America LLC 4747 N. Channel Ave. Here is what this code means: “Exhaust Emission Controller aftertreatent 1 intake gas sensor heater control mechanism system not responding or out of alignment.” That is a mouthful to say and to write. What this means is that the “NOx Raw Sensor not ready after Dewpoint enable inspection”. In other words, the sensor failed to activate.163. Wait to start light is not coming on. But engine starts. The wait to start light is for the engine intake air heater. When key is first turned on, all the lights on the dash come on for a couple of seconds, including the wait to start light. But it used to stay on for a few seconds after that, then go off signaling it was time to turn the ...

#1 · Apr 19, 2017. I have an 05 2500 with a stage 2 bd turbo, 90 over injectors and a smarty touch tuner. My grid heater light keeps coming on while I'm driving along with ten dings. …. Dovin funeral home lorain

intake heater light on freightliner

8 posts · Joined 2008. #1 · Jan 4, 2009. I have tested the relays (solenoids) now trying to test the actual grid heater just need to know how many ohms resistance should the element have. I know there is power to the heater just need to test the heater to make sure it is working correctly. Thanks for your time.The grid heaters on our Vision's here will continue to cycle causing the volt gauge to drop, the STOP light and TOO LOW with pic of battery, until the engine oil temp and the engine water temp reach 120 degrees cumulatively. So basically 60 degrees of temp on each one is suppose to stop grid heater from coming on.Cummins FC 383 Intake Heater Zach Melton 3 posts since Dec 8, 2014 Cummins FC 383 Intake Heater Jan 4, 2021 8:17 PM ... I also hooked a load light to the stud on the heater to verify there is voltage going to the Heater. Cummins Troubleshooting states the resistance of the Relay control side should be a minimum of 30 ohms.needing a little help on a FS65 freightliner school bus with a C-7 cat engine have a code of 70-5 intake heater current low need a wiring diagram of the grid heater circuit Thanks John: jperkins Active Member. USA 41 Posts. Posted - 10/12/2010 : 1:51:30 PM . note this is a 2006 model:1 03-02-2017, 11:53 PM. Have a strange issue going on this Freightliner with a DDEC6. The intake heater light comes on and the engine will idle down to 600rpm. Wait a while …C3-A Optional Fuel Water Separator Heater C4-C Left Park Lamp C4-L Right Park Lamp C4-D Left Marker Lamp C4-M Right Marker Lamp C3-N Turn Left Front/Side C1-G Turn … 808 Posts. Posted - 05/30/2017 : 10:18:04 AM. I have a DT466 that we got back from the dealer . They had to do some work on the engine we installed . There were wiring issues . When we got it back the wait to start light would come on for 5 or 6 seconds and go off . A couple days later went to start the bus the wait to start light wouldn't come ... There can be numerous reasons/causes for this code failure. 1. Test the individual and total injector return rates now. May be damaged injector nut, tube hole, rust in threads. 2. Test the output i.e. measure the output of the lift pump and the CP3, if either are low in volume or pressure, will cause the code. 3.Summary: Freightliner Service Bulletin for Front Axle Spacer Replacement. This service bulletin replaces the version dated 05/01/2016. This bulletin is updated to include the parts list. Some vehicles may exhibit a lean (right or left) due to weight. Communication Number: 20CSA-04, Date: 2020-03-20.76 posts · Joined 2011. #1 · Jul 30, 2011. I was driving today and the wait to start/glow plug light started flashing along with chimes. Now it's on permanently. Anyone know why that is. All other gauges read ok. No check engine light and truck starts and shuts down as normal. Any help would be appreciated.Custom-built Freightliner vehicles are equipped with various chassis and cab components. Not all of the information contained in this manual applies to every vehicle. For details …superman279. 2113 posts · Joined 2010. #17 · Jul 27, 2013. No start when cold (depending on what 'cold' is to you) is more likely injector related. As far as the grid heater light goes, check for codes with the key trick. '03 2500 QCLB 4x4 47RE One Piece Driveshaft.09 Air Intake . 09–01 Air Cleaner Element Inspection and Replacement ; 13 Air Compressor . 13–00 Safety Precautions ; 13–01 Air Compressor Inspection ; 15 Alternators and Starters . 15–00 Safety Precautions ; 15–01 Alternator, Battery, and Starter Checking ; 20 Engine Cooling/Radiator . 20–00 Safety Precautions ; 20–01 Radiator ...09 Air Intake . 09–01 Air Cleaner Element Inspection and Replacement ; 13 Air Compressor . 13–00 Safety Precautions ; 13–01 Air Compressor Inspection ; 15 Alternators and Starters . 15–00 Safety Precautions ; 15–01 Alternator, Battery, and Starter Connections Check ; 20 Engine Cooling/Radiator . 20–00 Safety Precautions ; 20–01 ....

Popular Topics